Product ID:NUCLEAR GRADE CERAMALLOY CL PLUS GRAY
MSDS Date:07/14/1992
FSC:8040
NIIN:00N033943
MSDS Number: BPTNK

PALMER INTERNATIONAL INC

WORCESTER, PA 19490
US

Emergency Phone: 215-584-4241

Info Phone: 215-584-4241

Preparer: F. LAUMAN

Cage: 00933

PALMER INTERNATIONAL, INC.

WORCESTER, PA 19490 US

Telephone: 610-584-4241

Cage: 00933

EPOXY RESIN

CAS: 25068-38-6

RTECS: KC2100000

Fraction By Weight: 23%

EPOXY PHENOL NOVOLAC RESIN; (EPOXY PHENOL NOVOLAC). LD50

CAS: 28064-14-4

Fraction By Weight: 2.5%

LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE IRRITATION. SKIN:
PROLONGED OR REPEATED CONTACT CAN CAUSE MODERATE IRRITATION,
DERMATITIS. INHALATION: NORMALLY NO PROBLEM UNLESS HEATED.
INGESTION: SLIGHTLY TOXIC.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES: FLUSH W/LRG AMTS OF H*2O LIFTING EYELIDS OCCAS FOR AT
LST 15 MIN. GET PROMPT MED ATTN. SKIN: WASH THORO WITH SOAP AND
WATER, REMOVE CONTAM CLTHG PROMPTLY; WASH CLTHG BEFORE REUSE.
INGEST: DO NOT INDUCE VOMIT! KEEP PERSON WARM, QUIET & GET MED
ATTN.ASPIR OF MATL INTO LUNGS DUE TO VOMIT CAN CAUSE CHEM PNEUM
WHICH CAN BE FATAL. INHAL: MOVE AFFECTED PERSON TO FRESH AIR.IF
BRTHG DFCLT, (SUPDAT)

Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER FOR COOLING MATERIAL STORED IN
VICINITY OF FIRE.
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:SMALL SPILL: SCRAPE UP/SOAK UP WITH ABSORBENT
MATERIAL. LARGE SPILL: SCRAP UP/SOAK UP WITH ABSORBENT MATERIAL.
COLLECT FOR DISPOSAL, THEN FLUSH HEAVILY WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE.
Other Precautions:NONE.

Respiratory Protection:IF TLV OF PROD IS EXCEEDED,A NIOSH/MSHA APPRVD
AIR SUPPLY RESP IS ADVISED IN ABSENCE OF PROPER ENVIRON CNTRL. OSHA
REGS ALSO PERMIT OTHER NIOSH/MSHA APPRVD RESP UNDER SPECIFIED
CNDTNS. ENGINEERING/ADM IN CNTRLS SHOULD BE IMPLEMENTED (SUPDAT)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves:NITRILE RUBBER GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH; SAFETY SHOWER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: ADMINISTER OXYGEN. IF BREATHING HAS STOPPED, GIVE
ARTIFICIAL RESPIRATION. KEEP PERSON WARM, QUIET, AND GET MEDICAL
ATTENTION. RESP PROT: TO REDUCE EXPOSURE.

HCC:N1
Boiling Pt:B.P. Text:392F,200C
Vapor Density:HVR/AIR
Spec Gravity:2.82
Evaporation Rate & Reference:NON VOLATILE
Appearance and Odor:GRAY PASTE
Percent Volatiles by Volume:0

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND ACIDS.
Stability Condition to Avoid:HEAT AND OPEN FLAME. MOISTURE
CONTAMINATION.
Hazardous Decomposition Products:MAY FORM CO AND CO*2; NO*X, OXIDES OF
SILICONE & NITROGEN.

Waste Disposal Methods:SMALL/LARGE SPILL: INCINERATE OR LANDFILL IN
ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.